在保證
山東燃氣鍋爐正常運作過程中，你知道關于燃氣鍋爐的作用及安全維護，就讓濟南聯眾供熱設備廠帶大家深入了解一下燃氣鍋爐吧！
In order to ensure the normal operation of Shandong gas-fired boiler, you know about the function and safety maintenance of gas-fired boiler. Let Jinan Lianzhong heating equipment factory take you to have a deep understanding of gas-fired boiler!
在小型燃氣鍋爐的運轉中嚴禁在沒有水或水的情況下熄滅，以免發作事故。假定發現小型燃氣鍋爐嚴重缺水，應立即中止供暖。 小型燃氣鍋爐冷卻后，找出緣由并掃除缺陷。 不要加水以防止爐子損壞。
In the operation of small gas-fired boiler, it is strictly prohibited to extinguish without water or water, so as to avoid accidents. If the small gas-fired boiler is found to be seriously short of water, the heating should be stopped immediately After the small gas boiler is cooled, find out the reason and remove the defect Do not add water to prevent damage to the furnace.
小型燃氣鍋爐的操作人員熟練控制小型燃氣鍋爐的性能，操作程序和工藝流程，以防止非法操作。 當爐子在冬天關閉時，排出鍋爐水以防止小型燃氣鍋爐凍結。 在夏季不運用小型燃氣鍋爐時，應將鍋爐水排干，并用石灰中止單調維護。
The operators of small gas-fired boiler shall be skilled in controlling the performance, operation procedure and process flow of small gas-fired boiler to prevent illegal operation When the furnace is shut down in winter, discharge the boiler water to prevent the small gas boiler from freezing When the small gas-fired boiler is not used in summer, the boiler water shall be drained and the monotonous maintenance shall be stopped with lime.
假定發現小型燃氣鍋爐的吸力減小，則應清潔爐子，并應用頸部或煙囪門內的橡膠軟管清洗自來水。 小煤氣鍋爐除垢可在運用1年后開啟，觀察沙井的水垢厚度，加上除垢劑除垢，還可參與5-10kg燒堿或鹽酸和水煮24爐。 -36h，除垢和洗濯爐。 根據當?shù)氐乃|(zhì)，每六個月中止一次清潔操作，以去除小型燃氣鍋爐的水垢。 否則，對流管容易結垢，招致對流管堵塞和燒壞。
If it is found that the suction of small gas-fired boiler is reduced, the furnace shall be cleaned and the tap water shall be cleaned with a rubber hose in the neck or in the chimney door The scale removal of small gas boiler can be started after one year's operation. Observe the scale thickness of the sand shaft, add the scale remover to remove the scale, and participate in 24 boilers of 5-10kg caustic soda or hydrochloric acid and boiling water -36h, descaling and washing stove According to the local water quality, the cleaning operation shall be stopped every six months to remove the scale of small gas-fired boiler Otherwise, the convection pipe is easy to scale, resulting in blockage and burning of the convection pipe.
燃氣鍋爐主要用于工業消費和供暖，如化工，制藥，造紙，印染，食品，包裝，泡沫等行業，醫院，醫院，學校，賓館，住宅等供暖和洗浴。通知您燃氣鍋爐安裝的留意事項。
Gas-fired boilers are mainly used for heating and bathing in industries such as chemical industry, pharmacy, paper making, printing and dyeing, food, packaging, foam, hospitals, hospitals, schools, hotels, houses, etc. Inform you of precautions for gas boiler installation.
1.燃氣鍋爐不得安裝在臥室或直接與臥室相連的房間內，不得安裝在空氣不光滑的公開室。
1. The gas boiler shall not be installed in the bedroom or the room directly connected with the bedroom, and shall not be installed in the open room where the air is not smooth.
2.燃氣鍋爐電源運用220V / HZ交流電源，銜接可靠的接地導線，以確保安全運用。
2. The power supply of gas boiler shall be 220V / Hz AC power supply, and reliable grounding wire shall be connected to ensure safe operation.
3.燃氣管道和燃氣熄滅器之間的銜接運用特殊的燃氣管道。
3. Special gas pipeline shall be used for connection between gas pipeline and gas extinguisher.
4.安裝燃氣管道后，翻開燃氣閥，檢查銜接部位能否有肥皂液透露。 假定有透露，關閉閥門以修理或改換密封，然后檢查燃氣鍋爐，直到?jīng)]有透露。
4. After installing the gas pipeline, turn over the gas valve and check whether there is soap liquid in the connecting part Assuming disclosure, close the valve to repair or replace the seal, then check the gas boiler until no disclosure.
5，鍋爐安裝平整或合理設計，盡量做短，少，厚，即盡量縮短管道，減少彎曲，管道直徑應厚實。
5. The boiler installation shall be flat or reasonably designed to be as short, few and thick as possible, that is to say, the pipe shall be shortened as much as possible and the bending shall be reduced, and the pipe diameter shall be thick.
6.自然循環中主管道的坡度和回水管道的坡度為3-5％。 不應構成波浪以防止管道中的氣體堵塞。 管道系統中的排氣管應放置在系統的較高點，不應安裝閥門。
6. The gradient of main pipeline and return pipeline in natural circulation is 3-5% Waves shall not be formed to prevent gas blockage in the pipe The exhaust pipe in the pipeline system shall be placed at the higher point of the system, and the valve shall not be installed.
7.將排水閥安裝在系統的較低點。 供水箱底部應高于供水管的較高點。 出風口不應由自動排氣閥替代。 閥門不應安裝且不應堵塞。
7. Install the drain valve at the lower point of the system The bottom of the water supply tank shall be higher than the higher point of the water supply pipe The air outlet shall not be replaced by automatic exhaust valve Valves shall not be installed and blocked.
8，燃氣鍋爐系統管道長，彎曲道路多，無坡度，加熱效果不好。 應安裝循環泵。 水泵應安裝在供水管道上，泵的尺寸應根據加熱面積選擇。
8. The gas boiler system has a long pipeline, many curved roads, no slope, and poor heating effect Circulating pumps shall be installed The water pump shall be installed on the water supply pipeline, and the size of the pump shall be selected according to the heating area.
9.安裝管道時，向外延伸，坡度應向下傾斜5°，以防止冷凝水向后活動，構成爐體腐蝕，管道周圍無易燃物質。
9. When installing the pipeline, it shall extend outwards with a slope of 5 ° downward to prevent the condensate from moving backward, forming the corrosion of the furnace body, and there is no inflammable substance around the pipeline.
The above is the introduction of Jinan Lianzhong heating equipment plant to gas boiler. For more information, please click http://m.tiaoi.com.cn
18678809986
